OSA's Digital Library

Optics Express

Optics Express

  • Editor: C. Martijn de Sterke
  • Vol. 16, Iss. 17 — Aug. 18, 2008
  • pp: 12973–12986

Photonic textiles for pulse oximetry

Markus Rothmaier, Bärbel Selm, Sonja Spichtig, Daniel Haensse, and Martin Wolf  »View Author Affiliations


Optics Express, Vol. 16, Issue 17, pp. 12973-12986 (2008)
http://dx.doi.org/10.1364/OE.16.012973


View Full Text Article

Enhanced HTML    Acrobat PDF (2152 KB)





Browse Journals / Lookup Meetings

Browse by Journal and Year


   


Lookup Conference Papers

Close Browse Journals / Lookup Meetings

Article Tools

Share
Citations

Abstract

Biomedical sensors, integrated into textiles would enable monitoring of many vitally important physiological parameters during our daily life. In this paper we demonstrate the design and performance of a textile based pulse oximeter, operating on the forefinger tip in transmission mode. The sensors consisted of plastic optical fibers integrated into common fabrics. To emit light to the human tissue and to collect transmitted light the fibers were either integrated into a textile substrate by embroidery (producing microbends with a nominal diameter of 0.5 to 2 mm) or the fibers inside woven patterns have been altered mechanically after fabric production. In our experiments we used a two-wavelength approach (690 and 830 nm) for pulse wave acquisition and arterial oxygen saturation calculation. We have fabricated different specimens to study signal yield and quality, and a cotton glove, equipped with textile based light emitter and detector, has been used to examine movement artifacts. Our results show that textile-based oximetry is feasible with sufficient data quality and its potential as a wearable health monitoring device is promising.

© 2008 Optical Society of America

OCIS Codes
(060.2370) Fiber optics and optical communications : Fiber optics sensors
(170.1460) Medical optics and biotechnology : Blood gas monitoring
(170.3890) Medical optics and biotechnology : Medical optics instrumentation
(170.6510) Medical optics and biotechnology : Spectroscopy, tissue diagnostics

ToC Category:
Medical Optics and Biotechnology

History
Original Manuscript: May 29, 2008
Revised Manuscript: July 31, 2008
Manuscript Accepted: July 31, 2008
Published: August 11, 2008

Virtual Issues
Vol. 3, Iss. 10 Virtual Journal for Biomedical Optics

Citation
Markus Rothmaier, Bärbel Selm, Sonja Spichtig, Daniel Haensse, and Martin Wolf, "Photonic textiles for pulse oximetry," Opt. Express 16, 12973-12986 (2008)
http://www.opticsinfobase.org/oe/abstract.cfm?URI=oe-16-17-12973


Sort:  Author  |  Year  |  Journal  |  Reset  

References

  1. J. W. Zheng, Z. B. Zhang, T. H. Wu, and Y. Zhang, "A wearable mobihealth care system supporting real-time diagnosis and alarm," Med. Biol. Eng. Comput. 45, 877-885 (2007). [CrossRef] [PubMed]
  2. C. N. Scanaill, S. Carew, P. Barralon, N. Noury, D. Lyons, and G. M. Lyons, "A review of approaches to mobility telemonitoring of the elderly in their living environment," Ann. Biomed. Eng. 34, 547-563 (2006). [CrossRef]
  3. E. R. Post, M. Orth, P. R. Gershenfeld, and N. Russo, "E-broidery�??Design and fabrication of textile-based computing," IBM Syst. J. 39,840-860 (2000). [CrossRef]
  4. F. Carpi and D. De Rossi, "Electroactive polymer-based devices for e-textiles in biomedicine," IEEE Trans. Inf. Tech. Biomed. 9, 295-318 (2005). [CrossRef]
  5. J. Coosemans, B. Hermans, and R. Puers, "Integrating wireless ECG monitoring in textiles," Sens. Act. A - Phys. 130, 48-53 (2006). [CrossRef]
  6. O. Ziemann, J. Krauser, P. E. Zamzow, and W. DaumPOF-Handbook (Springer, Berlin, 2. Rev. Ed., 2008).
  7. M. G. Kuzyk, Polymer Fiber Optics: Materials, Physics, and Applications (Taylor & Francis Ltd, Boca Raton, 2006). [CrossRef]
  8. J. Zubia and J. Arrue, "Plastic optical fibers: An introduction to their technological processes and applications," Opt. Fib. Technol. 7, 101-140 (2001). [CrossRef]
  9. US Patent 3�??508�??589.
  10. http://www.luminex.it
  11. http://www.brochiertechnologies.com
  12. http://www.lumitex.com
  13. X. Tao, Smart Fibres, Fabrics and Clothing (CRC Press, 2001). [CrossRef]
  14. X. Tao, Wearable electronics and photonics (CRC Press, 2005).
  15. M. A. El-Sherif, J. M. Yuan, and A. MacDiarmid, "Fiber optic sensors and smart fabrics," J. Int. Mat. Sys. Struct. 11, 407-414 (2000).
  16. X. M. Tao, "Integration of fibre-optic sensors in smart textile composites: Design and fabrication," J. Text. Inst. 91, 448-459 (2000). [CrossRef]
  17. A. Dhawan, T. K. Ghosh, and A. Seyam, "Fiber-Based Electrical and Optical Devices and Systems," Text. Progr. 36, 1-84 (2005).
  18. S. L. P. Tang and G. K. Stylios, "An overview of smart technologies for clothing design and engineering," Int. J. Clothing Sci. Technol. 18, 108-128 (2006). [CrossRef]
  19. C. Gopalsamy, S. Park, R. Rajamanickam, and S. Jayaraman, "The wearable motherboard: The first generation of adaptive and responsive textile structures (ARTS) for medical applications," J. Virtual Reality 4, 152-168 (1999). [CrossRef]
  20. A. D. Kersey, M. A. Davis, H. J. Patrick, M. LeBlanc, K. P. Koo, C. G. Askins, M. A. Putnam, and E. J. Friebele, "Fiber grating sensors," J. Lightwave Technol. 15, 1442-1463 (1997). [CrossRef]
  21. M. El-Sherif, K. Fidanboylu, D. El-Sherif, R. Gafsi, J. Yuan, K. Richards, and K. C. Lee, "A novel fiber optic system for measuring the dynamic structural behavior of parachutes," J. Int. Mat. Sys. Struct. 11, 351-359 (2000).
  22. T. Allsop. K. Carroll, G. Lloyd, D. J. Webb, M. Miller, and I. Bennion, "Application of long-period-grating sensors to respiratory plethysmography," J. Biomed. Opt. 12, 064003 (2007). [CrossRef]
  23. A. Grillet, D. Kinet, J. Witt, M. Schukar, K. Krebber, F. Pirotte, and A. Depre, "Optical Fiber Sensors Embedded Into Medical Textiles for Healthcare Monitoring," IEEE Sensors J. 8, 1215-1222 (2008). [CrossRef]
  24. W. Du, X. M. Tao, H. Y. Tam, and C. L. Choy, "Fundamentals and applications of optical fiber Bragg grating sensors to textile structural composites," Composite Structures 42, 217-229 (1998). [CrossRef]
  25. X. Tao, L. Tanga, W. Dua, and C. L. Choyb, "Internal strain measurement by fiber Bragg grating sensors in textile composites," Comp. Sci. Technol. 60, 657-669 (2000). [CrossRef]
  26. B. Yang, X. Tao, J. Yu, and H. Ho, "Compression Force Measured by Fiber Optic Smart Cellular Textile Composites," Text. Res. J. 74, 305-313 (2004). [CrossRef]
  27. S. Yuan, R. Huang, and Y. Rao, "Internal Strain Measurement in 3D Braided Composites Using Co-braided Optical Fiber Sensors," J. Mater. Sci. Technol. 20, 199-202 (2004).
  28. J. Schuster, M. Trahan, D. Heider, and W. Li, "Influence of fabric ties on the performance of woven-in optical fibres," Composites A 34, 855-861 (2003). [CrossRef]
  29. J. W. Berthold, "Historical review of microbend fiber-optic sensors," J. Lightwave Technol. 13, 1193-1199 (1995). [CrossRef]
  30. A. Masuda, T. Murakami, K. Honda, and S. Yamaguchi, "Optical Properties of Woven Fabrics by Plastic Optical Fiber," J. Text. Eng. 52, 93-97 (2006). [CrossRef]
  31. A. Endruweit, A. C. Long, and M. S. Johnson, "Textile composites with integrated optical fibres: quantification of the influence of single and multiple fibre bends on the light transmission using a Monte Carlo ray-tracing method," Smart Mater. Struct. 17, 015004 (2008). [CrossRef]
  32. J. S. Heo, J. H. Chung, and J. J. Lee, "Tactile sensor arrays using fiber Bragg grating sensors," Sens. Act.A-Phys. 126, 312-327 (2006). [CrossRef]
  33. S. R. Emge, and C. L. Chen, "Two-dimensional contour imaging with a fiber optic microbend tactile sensor array," Sens. Act.B-Chem. 3, 31-42 (1991). [CrossRef]
  34. D. T. Jenstrom, and C. L. Chen, "A fiber optic microbend tactile sensor array," Sens. Act. 20, 239-248 (1989). [CrossRef]
  35. M. Rothmaier, M. P. Luong, and F. Clemens, "Textile Pressure Sensor Made of Flexible Plastic Optical Fibers," Sensors 8, 4318-4329 (2008). [CrossRef]
  36. T. Khan, M. Unternährer, J. Buchholz, B. Kaser-Hotz, B. Selm, M. Rothmaier, and H. Walt, "Performance of a contact textile-based light diffuser for photodynamic therapy," Photodiagnosis and Photodynamic Therapy 3, 51-60 (2006). [CrossRef]
  37. B. Selm, M. Rothmaier, M. Camenzind, T. Khan, and H. Walt, "Novel flexible light diffuser and irradiation properties for photodynamic therapy," J. Biomed. Opt. 12, 034024 (2007). [CrossRef] [PubMed]
  38. V. Koncar, "Optical fiber fabric displays," Opt. Photon. News 16, 40-44 (2005). [CrossRef]
  39. A. Harlin, M. Mäkinen, and A. Vuorivirta, "Development of polymeric optical fibre fabrics as illumination elements and textile displays," AUTEX Res. J. 3, 1-8 (2003).
  40. http://www.lumalive.com
  41. B. O'Connor, K. H. An, Y. Zhao, K. P. Pipe, and M. Shtein, "Fiber Shaped Light Emitting Device," Adv. Mat. 19, 3897-3900 (2007). [CrossRef]
  42. S. S. Hardaker, and R. V. Gregory, "Progress toward dynamic color-responsive 'chameleon' fiber systems," MRS Bull. 28, 564-567 (2003). [CrossRef]
  43. O. Shapira, K. Kuriki, N. D. Orf, A. F. Abouraddy, G. Benoit, J. F. Viens, A. Rodriguez, M. Ibanescu, J. D. Joannopoulos, Y. Fink, and M. M. Brewster, "Surface-emitting fiber lasers," Optics Express 14, 3929-3935 (2006). [CrossRef] [PubMed]
  44. M. Mignanelli, K. Wani, J. Ballato, S. Foulger, and P. Brown, "Polymer microstructured fibers by one-step extrusion," Optics Express 15, 6183-6189 (2007). [CrossRef] [PubMed]
  45. A. F. Abouraddy, M. Bayindir, G. Benoit, S. D. Hart, K. Kuriki, N. Orf, O. Shapira, F. Sorin, B. Temelkuran, and Y. Fink, "Towards multimaterial multifunctional fibres that see, hear, sense and communicate," Nature Materials 6, 336-347 (2007). [CrossRef] [PubMed]
  46. R. Boushel, H. Langberg, J. Olesen, J. Gonzales-Alonzo, J. Bulow, and M. Kjaer, "Monitoring tissue oxygen availability with near infrared spectroscopy (NIRS) in health and disease," Scand. J. Med. Sci. Sports 11, 213-222 (2001). [CrossRef] [PubMed]
  47. R. Boushel and C. A. Piantadosi, "Near-infrared spectroscopy for monitoring muscle oxygenation," Acta. Physiol. Scand. 168, 615-622 (2000). [CrossRef] [PubMed]
  48. H. L. Edmonds, Jr., B. L. Ganzel, and E. H. Austin, 3rd, "Cerebral oximetry for cardiac and vascular surgery," Semin. Cardiothorac. Vasc. Anesth. 8, 147-166 (2004).
  49. M. Ferrari, L. Mottola, and V. Quaresima, "Principles, techniques, and limitations of near infrared spectroscopy," Can. J. Appl. Physiol. 29, 463-487 (2004). [CrossRef] [PubMed]
  50. J. C. Hebden, "Advances in optical imaging of the newborn infant brain," Psychophysiology 40, 501-510 (2003). [CrossRef] [PubMed]
  51. Y. Hoshi, "Functional near-infrared spectroscopy: potential and limitations in neuroimaging studies," Int. Rev. Neurobiol. 66, 237-266 (2005). [CrossRef]
  52. H. Obrig and A. Villringer, "Beyond the visible--imaging the human brain with light," J. Cereb. Blood Flow Metab. 23, 1-18 (2003). [CrossRef]
  53. V. Quaresima, R. Lepanto, and M. Ferrari, "The use of near infrared spectroscopy in sports medicine," J. Sports Med. Phys. Fitness 43, 1-13 (2003). [PubMed]
  54. D. R. Leff, O. J. Warren, L. C. Enfiel, A. Gibson, T. Athanasiou, D. K. Patten, J. Hebden, G. Z. Yang, and A. Darzi, "Diffuse optical imaging of the healthy and diseased breast: A systematic review," Breast Cancer Res. Treat. 108,9-22 (2008). [CrossRef]
  55. J. D. Tobias, "Cerebral oxygenation monitoring: near-infrared spectroscopy," Expert Rev. Med. Devices 3, 235-243 (2006). [CrossRef] [PubMed]
  56. M. C. Taillefer and A. Y. Denault, "Cerebral near-infrared spectroscopy in adult heart surgery: systematic review of its clinical efficacy," Can. J. Anaesth. 52, 79-87 (2005). [CrossRef]
  57. K. R. Ward, R. R. Ivatury, R. W. Barbee, J. Terner, R. Pittman, I. P. Filho, and B. Spiess, "Near infrared spectroscopy for evaluation of the trauma patient: a technology review," Resuscitation 68, 27-44 (2006). [CrossRef]
  58. M. Wolf, M. Ferrari, and V. Quaresima, "Progress of near infrared spectroscopy and imaging instrumentation for brain and muscle clinical applications," J. Biomed. Opt. 12,062104 (2007). [CrossRef]
  59. J. G. Webster, Design of Pulse Oximeters (IOP, Bristol, 1997). [CrossRef]
  60. A. Jubran, "Pulse Oximetry," Crit. Care 3, R11-R17 (1999). [CrossRef]
  61. D. T. Delpy, M. Cope, P. van der Zee, S. Arridge, S. Wray, and J. Wyatt, "Estimation of optical pathlength through tissue from direct time of flight measurement," Phys. Med. Biol. 33, 1433-1442 (1988). [CrossRef] [PubMed]

Cited By

Alert me when this paper is cited

OSA is able to provide readers links to articles that cite this paper by participating in CrossRef's Cited-By Linking service. CrossRef includes content from more than 3000 publishers and societies. In addition to listing OSA journal articles that cite this paper, citing articles from other participating publishers will also be listed.


« Previous Article  |  Next Article »

OSA is a member of CrossRef.

CrossCheck Deposited